Clean It Up
UK Window Cleaning Forum => Window Cleaning Forum => Topic started by: lee_dewing on September 28, 2009, 08:29:45 pm
-
hi, all
anyone have wcw backpack, just got one as a backup to my freedom trolley, which battery has died on.
Just used wcw backpack today was quite happy with but the water flow is a little bit slow?
which i am suprised about as 80 psi pump thought it would be blasting out.
anyone else experienced this have i got a dud?
It's o.k but just feel it needs a little bit more welly!
any advice guys
thanks lee.
-
Can't say the flow on mine blasts out.Good enough though.
-
its sude be 4l a minte
-
is batt fully charged???
-
Check the fuse. The flow dropped on mine when the fuse went.
-
yep,
battery fully charged, had on about 16hrs charge.
where is fuse?
when backpack showed up it would only work when plugged in with charger, this was because when i opened up found one of the leads was not connected to battery :(
-
its on the red wire to bat
-
Yep, red battery wire in a kind of clear round case.
What's the longest its been charged for ?
-
16 houwers
-
its sude be 4l a minte
lol the wcw backpack is not 4litres per minute.
a 100psi pump only gives 5.2 litres per minute and that is flat out.
it should be between 1.5 and 2 litres per minute. my backpack has a flow rate of 2 litres per minute which is more than enough for working WFP.
Matt
-
i think youl find that its 80 psi in wcw backpak iv just looked on ther site and it says 85 psi but im all most shor mines 80 , my lads is def a dif pump in it ,so i think ther puting in wot ever thay can get hold of
-
the backpacks are from China and they are made for spraying chemicals and pesticides. that is why you have a lance ands nozzles with the backpack.
-
yes i think we kow that .and youv got the shor flow one ,wicth is 100 psi the other one kone as WCW bp is a hudson one and is yelow
-
my backpack is the WCW one and bright yellow, the shurflo backpack has a flow controller I think or is the omni backpack.
-
My WCW back pack will empty itself in about 5 minutes if I leave the flow on full without restricting it.
Depends on the size jets you have on your brush of course, but on mine (the gardiner brush setup) I have twin jets of water squirting a good 4ft maybe 5ft or more straight up...way too high a flow so I restrict it to about 18 inches.
As a rule of thumb that gives you a flow rate of about a litre per minute, which I find perfect in most situations.
Regarding PSI and flowrate....
You can have a high flow rate with low PSI and the reverse with high PSI!!!
Ian
-
I'm confused.com ::)
sounds like i'm like craig 72 then.
are the fuses easy to get hold of if thats it?
flows just about good enough but on reading other posts before buying i was under impression water came out a bit too quick, so thats why you needed hozlelock connector with tap to turn flow down.
i have vikan hi-lo brush 2mm jets i think ian.
-
I'm confused.com ::)
sounds like i'm like craig 72 then.
are the fuses easy to get hold of if thats it?
flows just about good enough but on reading other posts before buying i was under impression water came out a bit too quick, so thats why you needed hozlelock connector with tap to turn flow down.
i have vikan hi-lo brush 2mm jets i think ian.
Check the flow rate from b/pack - fill up a two litre bottle and time it. 1min = 2Lpm 30sec's = 4Lpm etc etc .
Jets size: Stick a drill bit in the jet to guage what size the jets are. 2mm is a good size IMO.
Ian's right, psi and flow rate are specific to each pump and can vary. The PSi is just the cut off point. The flow rate is how much water the diaphragm is pushing through.
-
will take the measuring jug out tomorrow ;)
-
some one said a while back .the wcw backpack pump flow can b adjusted .said their was a screw some where in pump wheir flow can b adjusted . but he didnt say where it was .
-
no its psi that the srcue a justs .on the head of the pump is a small srcue holding the cover on under neth is the a juster ,iv not tuched mine ,but iv got a red hat pump looks the same pump and ajusted that one and iv got less flow on it by ajusting it its 80 psi and 4l minet , iv not checed the flow rate now but its def less flow .i run it thow 100m microw ,dont nowe if it wood be dif with sort hose or biger bor hose ,
-
thanks.
lee
-
thanks off me as well .
-
when backpack showed up it would only work when plugged in with charger, this was because when i opened up found one of the leads was not connected to battery :(
Well i finally got round to trying mine out today, been to busy since i got it monday to set it up and have a play, guess what? yes it would work unless it was plugged in, luckily i remembered this post and i have had a look and its the same fault. looks like someone aint checking there equipment properly before sending it out doesnt it ::)
-
yep,
It was funny; guy at wcw said very few things go wrong on these backpacks then said wires can come off.
As you say think they would check em :D
-
i never recieved the two pin plug either, so ive had to nick the wifes one from her toothbrush. ive e-mailed him and will wait to see his reply
-
they seem to have been a bit slap dash there!
did you order on a friday afternoon :D
I must admit it come through quick for me as i was in trouble due to battery dying on freedom trolley.
Got to get a battery for that this week, seems nothing but bills at mo.
Not much done today due to weather :'(
end of moan.
goodluck with your new backpack steve
lee
-
hi mate got a shurflo back pack you probably using on the highest flo setting this will drain power